Product ID:MIL-P-15930 REV-C COMP-G, VINYL ZINC PRIMER FORMULA 120
MSDS Date:10/16/1991
FSC:8010
NIIN:00-753-4714
MSDS Number: BVTYV

CRAWFORD LABS, INC

4165 S EMERALD AVE
CHICAGO, IL 60609
US

Emergency Phone: 312-433-1307

Info Phone: 312-376-7132

Cage: 5V430

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

ZINC CHROMATE

CAS: 13530-65-9

RTECS: GB3290000

Fraction By Weight: 5-20%

OSHA PEL C 0.1 MG (CRO3)/M3

ACGIH TLV: 0.01MG(CR)/M3,A1; 94

TAR ACIDS, CRESYLIC,PHENYL,PHOSPHATE

CAS: 68952-35-2

Fraction By Weight: 1-5%

METHYL ISOBUTYL KETONE (HEXONE) (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 20-50%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM/75 STEL; 9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 20-50%

OSHA PEL 200 PPM; Z-2

ACGIH TLV: S, 50 PPM; 9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE MAY RPODUCE VARIOUS
EFFECTS, INCLUDING: SEVERE EYE IRRITATION POSSIBLY RESULTING IN
PERMANENT BRAIN DAMAGE, SENSITIZATION AFTER REPEATED CONTACT,
DEFATTING AND DRYING OF THE SKIN, IRRITAT ED MUCOUS MEMBRANES
Explanation of Carcinogenicity:NONE
Effects of Overexposure:OVEREXPOSURE MAY PRODUCE VARIOUS EFFECTS,
INCLUDING: ACUTE TOXICITY, RESULTING IN HEADACHE, DIZZINESS,
NAUSEA, LOSS OF CONSCIOUSNESS, VOMITING DUE TO INGESTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE: FLUSH W/PLENTY OF WATER FOR 15 MINUTES. INHALATION:
REMOVE VICTIM TO FRSHAIR & PROVIDE OXYGEN IF BREATHING IS
DIFFICULT. NEVER GIVE AN UNCONSCIOUS PERSON LIQUIDS. INGESTION:
DON'T INDUCE VOMITING . IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD
BELOW HIPS TO PREVENT ASPIRATION OF LIQUIDS INTO THE LUNGS. SKIN:
FLUSH W/WATER & WASH W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN
ALL CASES.

Flash Point Method:SCC
Flash Point:45.0F,7.2C
Lower Limits:1.2%
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP EXPOSED CONTAINERS
COOL, & TO KEEP FLAMMABLE STRUCTURES WET. DO NOT ENTER FIRE AREA
WITHOUT PROPER PROTECTION.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.

Spill Release Procedures:WARNING: FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
WEAR PROTECTIVE CLOTHING. SOAP UP W/AN ABSORBANT & PLACE IN
NON-LEAKING CONTAINERS. SEAL TI GHTLY FOR PROPER DISPOSAL.

Handling and Storage Precautions:TREAT AS A HAZARDOUS-FLAMMABLE KNOWN
APPLICABLE D.O.T. REGULATIONS BEFORE ATTEMPTING TO TRANSPORT THIS
MATERIAL.
Other Precautions:IGNITION MAY OCCUR AT TYPICAL ELEVATED TEMPERATURE
PROCESS CONDITIONS, ESPECIALLY IN PROCESS OPERATING UN DER VACUUM
IF SUBJECTED TO SUDDEN INGRESS OF AIR OR OUTSIDE PROCESS.

Respiratory Protection:IMPORTANT-MUST PROVIDE ADEQUATE VENTILATION TO
MAINTAIN VAPOR CONCENTRATIONS BELOW THE ESTABLISHED TLV LIMIT AS
GIVEN BY OSHA. IN MORE CONFINED AREAS A NIOSH-MSHA APPROVED
RESPIRATOR EQUIPPED WITH ORG ANIC VAPOR CARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION, SEE PARAGRAPH ABOVE.
Protective Gloves:USE RUBBER GLOVES.
Eye Protection:SAFETY GOGGLES &/OR FACE SHIELD.
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & SHOES BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXTREMELY FLAMMABLE.

HCC:F2
Boiling Pt:B.P. Text:231-255F
Vapor Density:>AIR
Evaporation Rate & Reference:1.39 X (N-BUTYL ACETATE)
Appearance and Odor:GREEN LIQUID.
Percent Volatiles by Volume:80.4%

Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH STRONG OXIDIZING AGENTS & STRONG ALKALIES.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES AND
INCOMPATIBLES.
Hazardous Decomposition Products:MAY GENERATE HIGHLY POISONOUS CARBON
MONOXIDE AND OTHER TOXIC GASES.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.